Roads to ruin: the problem of potholes
Occasionally when cycling in France you will come across a road sign that says, “Chausée déformée”, followed by a section of road that is perhaps a bit on the bumpy side or contains the occasional pothole. I’ve always found this sign hilarious. If the standards used in France were adopted in Britain there would be many roads where this sign would have to be erected every few hundred metres over their entire length. To use that old saw: “you can tell how an economy is doing by the state of its roads.” By that reckoning parts of Britain are on the way to basket case territory.
When the routes for the 2012 Olympic cycle races were announced to run through London and Surrey I was delighted, thinking that at the very least a few of the battered roads would be resurfaced. Indeed in the hours before the ‘test event’ in August this year considerable emergency road repair took place. But the routes are still far from perfect and I was told, worryingly, that: “the quality of the road surface does not need to be perfect and Surrey County Council will maintain the Olympic cycling routes to a similar standard expected of our highways.”
A rough ride
If the current state of the roads is the “standard to be expected”, Olympian cyclists venturing to London next year better dig out their Paris-Roubaix bikes and start popping the ibuprofen in readiness. Thousands of cyclists have taken part in sportives and other events on or near the Olympic route and many more will take to the Surrey hills next year in the run up to the Games. From my experience of these roads in their current state I couldn’t recommend the use of narrow tyres or fragile racing rims.
For event organisers without the benefit of international scrutiny and millions of pounds riding on the event, the dire state of road maintenance is more of a headache. Due to the recent rapid deterioration of roads Graham Temple, the organiser of CTC’s Challenge Ride Series, had to invest in signs which are erected along his routes warning riders of loose gravel and other hazards. But, as he says, “if I signed every patch of gravel I’d need another team of drivers just to assist with that.”
In a recent major survey of residents of English councils Surrey’s roads were rated worst with the sole exception of Buckinghamshire, with satisfaction running at just 22% - far below most of the other issues surveyed. Nationally satisfaction with road surface condition has crumbled from 46% to 33% over the last 4 years, farther than for any other local authority action except winter gritting.
The hole truth
Why are our roads so poor for cycling when compared with our European counterparts? Blame has been pinned on recent winters and the periods of very cold weather and heavy snow that had become rare in many parts of the country. Given that our European neighbours had the same (or worse) winters, it seems more likely that the weather simply exposed an inherent weakness in our roads.
Over half of all local authority highway spending goes on road maintenance amounting to an eye-watering £2.3bn in England alone last year. The Audit Commission found that although spending in cash terms has risen by 73% since 2000, inflation in the industry (mainly due to the soaring cost of raw materials) has outpaced this – meaning that there has been no increase in purchasing power. Yet volumes of traffic and vehicle weight have both grown, increasing road damage.
One concern expressed by some figures in the road maintenance industry has been that with reduced resources councils have been spending more and more on expensive emergency repairs rather than longer term maintenance, resulting in a downward spiral of neglect and expensive, remedial repair. This has occurred despite some local authorities changing the definition of ‘pothole’. Defects now have to be 40 mm deep before action is taken, compared with a much tougher 25 mm that was used in some places until recently.
Councils are currently supposed to fix dangerous hazards within 24 hours. Some local authority engineers suggest it would be more cost effective waiting for high quality permanent solution rather than a temporary dump of asphalt. This may mean potholes lying unfixed for longer, which increases the council’s liability if injury or damage to property occurs – and people cycling are more likely to suffer from potholes than those in cars.
Cyclists are also particularly disadvantaged because the types of roads we use the most have seen the greatest decline in maintenance standards. 37% of cars mileage is done on minor roads, compared to 82% of cycle mileage, but major roads are deemed to be more important and have received higher priority in maintenance planning, leaving our lanes and cycle paths to crumble. Minor roads or cycle paths are inspected once a year or less, compared with once a month on the busiest road networks. A defect that appears on a country lane could – if not reported using fillthathole.org.uk – remain there for many months before the local authority even noticed it.
Stuck with the tar pits
Repairs on minor roads are often (literally!) slapdash. Uneven hand-laid reinstatements following utility works not only lead to potholes forming in the weakened road, it also means bumpy, uncomfortable and dangerous surfaces for cycling. Incorrect laying of materials at the wrong time of year or at the wrong temperature can result in premature failure of the surface.
It gets even worse on off-road. While some cycle paths are built and maintained to a high standard, a rather more common scenario is the narrow, undulating pavement conversion over which vegetation has steadily encroached. In places where cycling is treated as a high priority – for example, the Netherlands or Denmark - maintenance on cycle paths and roads used for cycling receives a higher standard of maintenance than the road network.
Professor John Parkin of London South Bank University points out that although road engineers are accustomed to providing smooth surfaces for drivers, they often don’t understand that smooth surfaces are more important for self-propelled cyclists. Rough or bumpy surfaces make cycling much harder – especially for those whose only suspension is 23 mm tyres.
With the next pothole season getting underway, local authorities (and cyclists!) will be hoping that it won’t be as cold and snowy as the last two winters. In 2010 the Government stumped up £100 million for emergency road repairs and this year they gave another £200 million. Next year such largesse is unlikely. If we are ever to get back on top of the problem a higher proportion of the billions spent each year needs to be on longer term maintenance, not on gangs roaming the road network with barrels of boiling bitumen and sacks of chippings.
How do potholes form?
Roads deteriorate gradually over time – the surface gradually crumbles due to natural weathering and the aging process of bitumen, which becomes more brittle with age. The passage of vehicles – particularly heavy vehicles - can lead to cracking which then allows water into the road surface. In winter repeated cycles of freezing and thawing of the water under the surface leads to expansion, heaving the surface up and enlarging the crack, allowing more water to enter. This cycle repeats, increasing the size of the hole. Vehicle tyres entering a flooded hole also cause pressure waves which can further erode the road foundation, pushing loose material out of the hole deepening and widening it.
How to stop potholes forming:
- Inspect surfaces regularly – a good programme of inspection, augmented by individual reports using tools like fillthathole.org.uk can help councils determine where the priority areas for repair are.
- Keep roads well drained – clear ditches, culverts and drains regularly and engineer roads to be clear of standing water. Flooded roads can erode the surface and water to enter through cracks.
- Ensure surfaces are watertight – regular maintenance can prolong the life of the road and ensure it remains watertight by sealing it with a thin layer of asphalt and chippings often described as ‘surface dressing’. Badly designed, however, this can make roads rougher.
- Minimise utility works and check quality of repair – road works are often blamed for causing delays and congestion. They also lead to potholes forming as the opening of the road weakens the structure, often leading to potholes forming. Local authorities must also check up on the quality of the reinstated carriageway to ensure that the utility company’s contractor has done a decent job.
- Regularly resurface – all roads will fail eventually. It is often much more expensive to continually repair a failing road than to undertake a full resurfacing.
- Reduce traffic – the volume of traffic, particularly heavy vehicles, is the main cause of initial road surface failure. Restricting the use of large vehicles on minor roads can ensure that they stay in better condition for longer.
Filling that Hole since 2007
For decades Cycling UK distributed ‘pothole report cards’ to members and forwarded the returns to the relevant council officials. That process was eased with the creation of the www.fillthathole.org.uk website and smart phone apps in 2006. All you need do now is log the location of a road defect on the map, fill in a few details and Cycling UK sends it on to the local authority responsible.
Since 2006 over 60,000 reports have been recorded - over 20,000 in the last year alone. The apps for both Android and Apple's iOS has also proved very popular, giving people the chance to locate, photograph and log a pothole while out cycling.
Cycling UK’s role in this area has caught the attention of local authorities, some of whom have enthusiastically welcomed the contribution. In the past, we have run competitions between local authorities to establish which was the fastest at responding to reports and which local authorities were deemed the best at fixing hazards by the sites’ users, with Cheshire West and Chester Council scooping the main prize for speed of response back in 2011.
Find out more at www.fillthathole.org.uk